Product ID:PRIMER EXTERIOR ALKYD, 5-99
MSDS Date:03/03/1993
FSC:8010
NIIN:00N063373
MSDS Number: BYZJJ

PRESERVATIVE PAINT CO

5502 AIRPORT WAY SO
SEATTLE, WA 98108
US

Emergency Phone: 800-424-9300 (CHEMTREC)

Info Phone: 206-763-0300

Cage: 86589

PRESERVATIVE PAINT CO

80387 SEATTLE, WA 98108-1726 US

Cage: 86589

2

CAS: 8052-41-3

RTECS: WJ8925000

Fraction By Weight: 25-35%

OSHA PEL 500 PPM

ACGIH TLV: 100 PPM

TITANIUM OXIDE; (TITANIUM DIOXIDE)

CAS: 13463-67-7

RTECS: XR2275000

Fraction By Weight: 15%

OSHA PEL 15 MG/M3 TDUST

ACGIH TLV: 10 MG/M3 TDUST

TALC (POWDER), CONTAINING NO ASBESTOS FIBERS; (MAGNESIUM

CAS: 14807-96-6

RTECS: WW2710000

Fraction By Weight: 35%

OSHA PEL 20 MPPCF

ACGIH TLV: 2 MG/M3 RDUST

SILICA, CRYSTALLINE - QUARTZ; (SILICA)

CAS: 14808-60-7

RTECS: VV7330000

Fraction By Weight: 4.30%

OSHA PEL N/K

ACGIH TLV: 0.1 MG/M3 RDUST

2.93 LB/GAL (351 G/L) MATERIAL &

RTECS: 9999999VO

OSHA PEL N/K

ACGIH TLV: N/K

LEAKAGE. GROUND CNTNRS WHEN POURING. WASH

RTECS: 9999999ZZ

STORE ABOVE 100F. KEEP & STORE OUT OF REACH OF

RTECS: 9999999ZZ

THIS MATERIAL KEEP SPRAY BOOTH CLEAN. AVOID

RTECS: 9999999ZZ

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:UNDER NORM CONSUMER USE CNDTNS
LIKELIHOOD OF ANY ADVERSE HLTH EFTS ARE LOW. OVERSPRAY/MISTS ARE
PRIMARILY CONSIDERED NUISANCE DUST - PIGMENTS NOT NORM CONSIDERED
HAZ IN MIX. INHAL: MAY CAUSE NOSE & TH ROAT IRRIT. MAY CAUSE
NERVOUS SYS DEPRESS CHARACT BY FOLLOWING STEPS: HDCH, DIZZ, NAUS,
STAG GAIT, (EFTS OF OVEREXP)
Explanation of Carcinogenicity:SILICA, CRYSTALLINE-QUARTZ: IARC MONO,
SUPP, VOL 7, PG 341, 1987:GROUP 2A. NTP 7TH ANNUAL REPORT ON
CARCINS, (SUPDAT)
Effects of Overexposure:HLTH HAZ: CONFUSN & UNCON. SKIN: RPTD/PRLNG LIQ
CNTCT MAY CAUSE IRRIT W/DISCOMFORT & DERM. ABSORPTION: REDNESS OF
SKIN W/BURNING SENSATION. EYES: MAY CAUSE IRRIT/BURNING. INGEST:
MAY CAUSE GI DISTRESS . OVEREXP TO SOLVS MAY CAUSE CNS DEPRESS,
CARDIOPULMONARY FAILURE, LIVER & KIDNEY DMG & BIRTH DEFECTS.
CHRONIC: (SUPDAT)
Medical Cond Aggravated by Exposure:PRE-EXISTING CONDITIONS INVOLVING
SKIN, LIVER, KIDNEY AND PULMONARY DISORDERS.

First Aid:EYES: FLUSH WITH WATER FOR AT LEAST 15 MINUTES. CALL MD.
SKIN: REMOVE CONTAMINATED CLOTHING & WASH EXPOSED AREA WITH SOAP &
WATER. INHAL: REMOVE TO FRESH AIR. IF NOT BREATHING, GIVE
ARTIFICIAL RESPIRA TION, PREFERABLY MOUTH-TO-MOUTH. IF BREATHING
DIFFICULTY PERSISTS OR OCCURS LATER, CONSULT MD. INGEST: CALL MD
IMMEDIATELY. DO NOT INDUCE VOMITING.

Flash Point Method:TCC
Flash Point:105F,41C
Lower Limits:1.0%
Upper Limits:6.0%
Extinguishing Media:FOAM, CARBON DIOXIDE, DRY CHEMICAL, WATER FOG,
OTHER.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT . COOL CLOSED CONTAINERS WITH WATER FOG TO
PREVENT PRESSURE BUILDUP.
Unusual Fire/Explosion Hazard:KEEP CNTNRS CLSD. VAP IS DENSER THAN AIR
& CAN TRAVEL & COLLECT IN LOW SPOTS. ISOLATE FROM HEAT, ELEC EQUIP,
SPKS & OPEN FLAME. CLSD CNTNRS MAY EXPLODE (SUPDAT)

Spill Release Procedures:VENTILATE AREA. REMOVE ALL SOURCES OF
IGNITION. PREVENT SKIN CONTACT AND BREATHING OF VAPORS. CONFINE AND
REMOVE WITH INERT ABSORBENT MATERIAL. USE SPARK PROOF TOOLS.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:OBSERVE LABEL PRECS. KEEP AWAY FROM
EXCESSIVE HEAT, SPKS & OPEN FLAME. KEEP CLOSURES TIGHT WHEN NOT IN
USE. STORE IN UPRIGHT POSITION TO PVNT (ING 6)
Other Precautions:DO NOT SAND, FLAME CUT, BRAZE OR WELD DRY COATING
W/OUT WEARING NIOSH/MSHA APPRVD RESP OR APPROP VENT. CNTNRS OF THIS
MATL MAY BE HAZ WHEN EMPTIED. SINCE EMPTY CNTNRS RRETAIN RESIDUES,
ALL HAZ PRECS M UST BE OBSERVED. WHEN SPRAYING (ING 8)

Respiratory Protection:PROPERLY FITTED VAPOR/PARTICULATE RESPIRATOR
APPROVED BY NIOSH/MSHA.
Ventilation:SUFFICIENT IN PATTERN & VOL TO KEEP VAPS BELOW APPLIC OSHA
REQUIREMENTS. USE EXPLOS-PROOF MECHANICAL DEVICE IF REQUIRED.
Protective Gloves:SOLVENT IMPERVIOUS GLOVES.
Eye Protection:ANSI APPRVD CHEM WORKERS GOGGLES .
Other Protective Equipment:ANSI APPRVD EYE WASH & DELUGE SHOWER .
COVERALLS ARE RECOM. SOLV IMPERVIOUS APRON RECOM IF BODY CNTCT MAY
OCCUR.
Work Hygienic Practices:WASH CONTAMINATED CLOTHING BEFORE REUSE.
PERIODIC MONITORING OF EXPOSURE LEVELS/LIMITS IS RECOMMENDED.
Supplemental Safety and Health
EXPLO HAZ: WHEN EXPOSED TO EXTREME HEAT. DO NOT APPLY TO HOT SURFS. CAN
CAUSE SPONT COMBUST (CONTAMD RAGS, ETC). EXPLAN OF CARCIN: 1994:
ANTIC TO BE CARCIN. ANIMAL:LUNG. EFTS OF OVEREXP: REPORTS HAVE
ASSOC RPTD & PRLNG OVEREXP TO SOLVS W/PERM BRAIN & NERVOUS SYS DMG.

Boiling Pt:B.P. Text:334F,168C
Vapor Pres:SEE ING 1
Vapor Density:HVR/AIR
Spec Gravity:1.4 (H*2O=1)
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:NEGLIGIBLE
Appearance and Odor:CLEAR AND PIGMENTED COATINGS WITH CHARACTERISTIC
ODOR.

Stability Indicator/Materials to Avoid:YES
MAY REACT WITH STRONG OXIDIZING MATERIALS.
Stability Condition to Avoid:NONE REASONABLY FORSEEABLE.
Hazardous Decomposition Products:OXIDES OF CARBON.

Waste Disposal Methods:DO NOT ALLOW MATERIAL TO CONTAMINATE GROUND
WATER SYSTEMS. DISPOSE OF ABSORBED MATERIAL IN ACCORDANCE WITH
FEDERAL, STATE AND LOCAL REGULATORY REQUIREMENTS. DO NOT INCINERATE
IN CLOSED CONTAINERS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.